Staple Bend Tunnel Trail

The Staple Bend Tunnel Trail follows the path of the Allegheny Portage Railroad to the first railroad tunnel in the country, the 901 foot long Staple Bend Tunnel. The railroad, an engineering landmark, lifted canal boats over the Allegheny Mountains in the 1830's, 40's and 50's. This trail, Managed by the National Park Service, allows the visitor to walk or bike to the nation's first railroad tunnel.

photo: A view of the Staple Bend Trail from inside of the Staple Bend Tunnel. Type: Backcountry
Fitness Trail
Greenway
Mountain Bike Trail
Nature Trail
Rail Trail
Length: 2.50 miles
Loop Trail? No
Allowed Uses: Bicycling (on pavement), Bicycling (off pavement), Pedestrian - Walking/Hiking/Running, Roller/Inline Skating, Snow - Cross-country Skiing
Agency: Nonprofit
Entry Fee? No
Parking Fee? No

See more details.

Become an NRT Ambassador

Join a cadre of volunteers to help improve the data on this trail.

Directions

Location: Mineral Point, PA
States: Pennsylvania
Counties: Cambria
Latitude: 40.376542   Longitude: -78.835384

Take US Route 22 to the Mundy's Corner/Nanty Glo exit. Turn right onto PA Route 271 South. Continue on Route 271 South approximately 5 miles until a (marked) left turn onto Mineral Point Road (PA 3030). After approximately 2 miles make a (marked) right turn onto Beech Hill Road and proceed over the bridge. Go through the railroad underpass (wait for the green light!); the paved parking lot for Staple Bend Tunnel will be located on the right. Please used the parking lot and do not block the emergency access road. This same parking area is used for the Path of the Flood trail as well.

Description

The Staple Bend Tunnel trail is one segment of the Pittsburgh to Harrisburg Main Line Canal Greenway. The trail has two surfaces which will serve two populations. The 2.5 mile trail is level with a limestone surface that caters to recreational exercise. The trail also is the only access to the Staple Bend Tunnel, a unique tunnel with exemplary stone masonry and exposed rock.
This trail has several features that set it apart from any rail trail in the world. First and foremost is Staple Bend Tunnel, the first railroad tunnel completed in America. It was the third tunnel of any kind built in the U.S., the first tunnels were for other canals in Pennsylvania. Work began on the tunnel on November 21, 1831 and often occured during inclement conditions. The men were paid $13 per month plus room and board for 12 hour days 6 days per week. Workers chipped and blasted 901 feet of solid rock to make the tunnel.
Approximately 14,900 cubic yards of bedrock was removed using black powder blasting. This was done by drilling three feet long holes and packing them with powder. Drilling one typical hole took up to three hours of hard effort using a three man crew. Nine to ten holes, each one-inch in diameter and thirty-six inches in length, were made before blasting. One pound of explosive powder wrapped in paper was pushed into each hole, tamped down, punctured with a sharp needle, and a fuse added. Fuses were lit with explosions to occur at mealtime. Workers would eat while the dust settled then get to work cleaning (mucking) the tunnel. Of the 36-inch hole drilled only 18 inches, or half of the hole, was blasted.
The tunnel grew about 18 inches each day, with both sides moving toward the center. On December 21, 1832 the workmen broke through the final barrier and connected the two ends of the tunnel. There was much celebration with speeches and toasts. The full tunnel excavation was completed in April 1833.
The ends of the Staple Bend Tunnel were lined with cut stone for safety. Rock and dirt might fall due to rain or other weather, or from the effects of the portage railroad going through the tunnel. The fancy entranceways to the tunnel were to impress the travelers and the general public. The style was described as a "Roman Revival style with low relief lintel supported by Doric pilasters on each side." Of the money spent (the total cost was $37,498.85), nearly half was to build the entrance ways.
The mark (signature) from the early 19th century stonecutters can still be seen on several blocks (bring a flashlight). The rest of the tunnel is natural bare rock.
Along the trail are several rows of existing stone “sleepers” used as railroad ties in the 1800's. Once through the tunnel, you are standing at the top of the first of a series of 10 inclines used to transport canal boats loaded on rail cars across the Allegheny Mountains, connecting Philadelphia and Pittsburgh and beyond. The Staple Bend Tunnel Trail is part of a larger trail system known as the “Path of the Flood Trail,” which follows the route of the 1889 Johnstown Flood from South Fork to Johnstown along the Little Conemaugh River.

Additional Details

Primary Surface: Crushed Rock
Secondary Surface: Grass or Vegetation
Gravel
Snow or ice

Average Grade: 1%
Elevation Low Point: Not Available
Elevation High Point: Not Available
Year Designated: 2009

Supporting Webpages and Documents

Document: Eastern portal of the historic Staple Bend Tunnel
Document: Western portal of the historic Staple Bend Tunnel.

Contact Information

For more information and current conditions, contact the trail manager (listed below). For questions, suggestions, and corrections to information listed on the website, contact American Trails.

Trail Management:
Keith Newlin
Acting General Superintendent, Western Pa. Parks
National Park Service
l10 Federal Park Drive
Gallitzin , PA 16641
(814) 886-6121
keith_newlin@nps.gov
http://www.nps.gov/alpo

 

Photos

No additional photos are available.

Reviews

No reviews are available. Be the first to leave one!

 

Suggest an Edit

Do you see a problem with this trail data? Contact us below: